PENGARUH VARIASI TEKANAN PENCETAKAN TERHADAP KARAKTERISTIK BRIKET BERBAHAN KAYU SENGGANI DAN KULIT KAYU BAKAU

  • Erik Taurik Septian Universitas Bangka Belitung
  • Eka Sari Wijianti Universitas Bangka Belitung
  • Saparin Saparin Universitas Bangka Belitung

Abstract

ABSTRACT

 

Senggani plant (Melastoma Candidum d. Don) is a plant that grows wild in a place that gets sufficient sunlight, such as in the fields, in the Bush and on the edge of the Marsh that is not be used at all so is the abundance of waste charcoal form mangrove bark a lot there is a Pagarawan village charcoal in craftsman wasted. Therefore the aim of this research is utilizing both such material as a fuel alternative that is briquettes. As the main ingredients of this research using 100% wood senggani and 100% mangrove bark charcoal with pressure 80 Psi, 100 Psi and 120 Psi. Drying using an electric oven with a temperature of 600 C for 24 hours. The emphasis/briquette presses, this process was intended to batter briquettes with effectiveness and results to good. The results showed that the value of the lowest water levels on treatment with pressure 80 Psi-based mangrove bark of 13.85%. The value of the lowest levels of ash on treatment with pressure 100 Psi made from wood senggani of 1.62%. The highest heat value is present on the treatment with pressure 80 Psi-based mangrove bark of 5366.35 CAL/g. test results drop shatter test showed good briquettes index, because it is not the destruction of briquettes while the testing done as high as 1.8 m. Results obtained at the treatment the best briquettes 100% wood charcoal senggani with 120 Psi pressure mengasilkan low levels of ash of 1.62% even though the value of the heat does not meet the standards.

Keywords: Senggani wood, Briket, Mangrove Bark, Moisture, ash, calorific value

Downloads

Download data is not yet available.

References

[1] Energia. 2013. Lampu Kuning Cadangan Minyak Indonesia. Jakarta: Pertamina Indonesia, 12(XLVI).
[2] Sembiring, Sudiro, Sigit Suroto. 2014. Pengaruh Komposisi Dan Ukuran Serbuk Briket Yang Terbuat Dari Batubara Dan Jerami Padi Terhadap Karakteristik Pembakaran. Jurnal Sains Tech Politeknik Indonusa Surakarta ISSN: 23555009 Vol 2 Tahun 2014. Surakarta.
[3] Budiman, Sukrido, & Harliana. 2010. Pembuatan bio-briket dari campuran bungkil biji jarak pagar (Jatropha curcas l.) dengan sekam sebagai bahan bakar alternatif. Prosiding Seminar Rekayasa dan Proses Tahun 2010, Semarang: Universitas Diponegoro.
[4] Walpole, E Ronald dan Raymond H myers. Ilmu peluang statistika untuk insinyur ilmuan, edisi ke-4, ITB Bandung 1995.
[5] Mangkau, Andi dkk. 2011. Penelitian Nilai Kalor Briket Tongkol Jagung Dengan Berbagai Perbandingan Sekam Padi. Prosiding Hasil Penelitian Fakultas Teknik Universitas Hasanudin. Makassar.
[6] Yuda, Dodi. 2003. Skripsi. Fakultas Pertanian.Universitas Sumatra Utara. Medan.
[7] Asmahwandri. 2016. Pengaruh Jumlah Perekat Terhadap Kualitas Briket Dengan Variasi Campuran Bahan Bambu (Bamboo) Dan Rumput Setaria (Setaria Sphacelata) Jurusan Teknik Mesin Universitas Bangka Belitung 2016.Bangka Belitung.
[8] Jeki. 2016. Karakteristik Briket Dengan Bahan Campuran Kayu Pelawan Dan Batang Resam. Jurusan Teknik Mesin Universitas Bangka Belitung 2016.Bangka Belitung
Published
2017-07-03
Abstract viewed = 65 times
PDF (Bahasa Indonesia) downloaded = 122 times

Most read articles by the same author(s)